Polímeros: Ciência e Tecnologia
https://app.periodikos.com.br/journal/polimeros/article/doi/10.1590/S0104-14282002000200007
Polímeros: Ciência e Tecnologia
Scientific & Technical Article

Preparação e Avaliação Térmica e Reológica de Misturas de PEBD/PELBD

Preparation of LDPE/LLDPE Blends and Thin Rheological and Calorimetric Evaluation

Becker, Márcia R.; Forte, Maria Madalena de C.; Baumhardt Neto, Ricardo

Downloads: 3
Views: 1005

Resumo

Misturas de Polietileno de Baixa Densidade (PEBD) com diferentes tipos e proporções de Polietilenos Lineares de Baixa Densidade (PELBD) foram preparadas em extrusora de rosca simples e dupla a fim de verificar a influência destes últimos na viscosidade e cristalinidade das misturas. As misturas de PEBD com PELBD foram avaliadas através de reometria capilar e calorimetria (DSC). As misturas de PEBD com PELBD com comonômero de 1-buteno e de 1-octeno, preparadas em extrusora de rosca simples ou dupla, não apresentaram diferenças no perfil das curvas reológicas. Entretanto, as misturas de PEBD com PELBD com comonômero 1-hexeno apresentaram diferenças nas curvas de viscosidade. Verificou-se que a adição de PELBD na mistura modifica significativamente a viscosidade principalmente em altas taxas de cisalhamento. Pela avaliação das curvas de fusão, observou-se que o aumento da concentração de PELBD nas misturas provoca uma variação no comportamento térmico das mesmas com o conseqüente alargamento da faixa de fusão.

Palavras-chave

Misturas, PELBD, PEBD, reologia capilar, DSC, polietilenos

Abstract

LDPE and LLDPE blends were prepared in a single and twin screw mixer, using different kinds and proportions of the LLDPE in order to evaluate their influence on the viscosity and cristallinity of the blends. The blends with LLDPE made with butene or hexene or octene comonomer, prepared in a twin or single screw mixer, did not show significant differences in their curves of viscosity versus shear rate. The addition of LLDPE in the PEBD changes the viscosimetric behavior of the blends especially at higher shear rate. With Differential Scanning Calorimetry we observed that the incorporation of LLDPE in the blends changes the behavior of melting curves due to its different types of crystallites.

Keywords

Blends, LLDPE, LDPE, capillary rheology, DSC, polyethylene

References



1 Dobrescu, V.; Andrei, G.;Cimpeanu, A. and Andrei, C. -Revue Roumaine de Chimie, 33, 4, 399 ¾ 403 (1988).

2 Huizenga, Darin; Chornoby, Kurt and Engelmann, Paul V. -Journal of Plastic Film & Sheeting, vol. 6 (1990).

3 Wong, A. C-Y & Sy, A. D. E. Journal of Materials Science,V. 30, p. 5672-5680, (1995).

4 Yamaguchi, Masayuki & Abe, Shigehiko. Journal of Applied Polymer Science, Vol. 74, 3153-3159, (1999).

5 Xu, X., L. Union Carbide Corporation. Bound Brook Technical Center, (1996). 9p.

6 Lee, Hoseok et al. J Polym Sci, Polym Phys Ed, 35, 1633, (1997).

7 Goyal, S. K., Bohnet, N. & Aubee, N. ¾"LLDPE/LDPE Blends: Effect of Composition on the Rheological and Physical Properties", in: ANTEC 95, 3221 (1995).

8 Forte, Maria Madalena e Miranda, Márcia S Lacerda. -Química e Derivados, março (1995).

9 Hamielec, Archie E. and Soares, João B. P. -Prog. Polym. Sci. Vo. 21, 651-706 (1996).

10 Childress, B. C. "Characterization of Conventional Low Density/ Linear Low Density Polyethylene Blends", in: MetCon'94, May 25-27, Houston, Tx, USA (1994).

11 Sasaki, Toshio; Ebara, Takeshi and Johoji, Hirofumi. -Polymers for Advanced Technologies, vol. 4, 406-414 (1992).

12 Pizzol, M. F. D. ¾ "Estudos das Estruturas de Polietilenos Lineares de Baixa Densidade Obtidos com Catalisadores Ziegler-Natta e Metaloceno" , Dissertação de Mestrado, Universidade Federal do Rio Grande do Sul, Brasil (1997)

13 Gunderson, J. J. e Parikh, D. R. ¾"Characterization of Conventional Low Density/Linear Low Density Polyethylene Blends" ¾Dow Chemical S.A.

14 Catálogo de Produtos da Politeno Indústria de Comércio S. A.

15 Manual de Extrusão de Filme da Ipiranga Petroquímica. Maio (1999).

16 Wendlandt, W. W.- "Thermal Analysis", John-Willey, New York,(1986).

17 Wood-Adams, P. et al. Macromolecules, 33, 7489-7499, (2000).

18 Cowie, J. M. G. ¾"Polymers: Chemistry and Physics of Modern Materials", Blackie Academic & Professional (1996).

19 Wadud, S. E. B. & Baird, D. G. J. Rheol, 44(5), 1151-1167, 2000.

20 Wood-Adams, P. J. Rheol. 45 (1), 203-210, 2000.

21 Prasad, A.; Mowery, D. ¾"A Quantitative Analysis of LDPE/LLDPE Blend Using DSC and FTIR Méthods", in: Antec'97, 987 (1997).

22 Hill, M. J. & Puig, C. C. Journal of Applied Polymer Science. 65, 1921-1931, (1997).

23 Brydson, J. A. ¾"Plastics Materials", Butterworth-Heinemann (1996)
588370e77f8c9d0a0c8b461e polimeros Articles
Links & Downloads

Polímeros: Ciência e Tecnologia

Share this page
Page Sections